The EZGO TXT has earned a loyal following for its reliability, simple construction, and long service life. Yet even the most dependable golf cart develops issues over time. Whether your EZGO TXT is electric or gas-powered, understanding common failure points helps you fix problems faster, reduce downtime, and extend the cart’s lifespan.

This guide walks you through the most common EZGO TXT problems, the symptoms you’ll notice, and practical troubleshooting steps. When a part needs replacing, we also point you toward compatible, high-quality 10L0L components available on our website.

1. Battery and Charging Problems (Electric TXT)

Battery-related issues remain the most frequent cause of poor performance in EZGO TXT electric models. Even one weak 6-volt battery in the pack can cripple the entire system.

Common symptoms

• Cart won’t move even though accessories power on

• Rapid voltage drop under load

• Charger won’t turn on

• Burning smell or bulging battery cases

What to check

1. Test each battery individually (not just pack voltage).

2. Clean and tighten all terminals to remove corrosion.

3. Ensure the charger is functioning and compatible.

4. Inspect battery cables for fraying, heat damage, or loose lugs.

If your cables need replacing, see our 48V and 36V Golf Cart Battery Cables in the EZGO Parts section for reliable, high-conductivity replacements.

2. Solenoid, Controller, and Wiring Faults

If your TXT clicks but doesn’t move — or stops suddenly mid-ride — the problem often lies within the solenoid, controller, or high-amp wiring.

Typical symptoms

• Pedal pressed: no movement

• No solenoid click

• Intermittent power loss

• Hot cables or melted terminals

Troubleshooting

• Verify solenoid activation when the pedal is pressed.

• Inspect the Forward/Reverse switch for burnt contacts.

• Check the main fuse or inline fuses.

• Inspect controller plug terminals for corrosion or heat marks.

• Look for rodent-damaged wires, especially under the seat.

If your TXT needs new electrical components, browse our Switches, Controllers, and Electrical Parts category for compatible replacements.

3. Motor and Rear Axle Issues (Electric TXT)

As the motor ages, brushes wear down and internal heat increases, leading to reduced performance.

Signs of motor trouble

• Slow acceleration

• Weak climbing power

• Burning odor

• Grinding sounds from the rear

Troubleshooting

• Inspect motor terminals for looseness or corrosion.

• Check for overheating after short rides.

• Listen for grinding or humming from the differential.

4. Fuel and Ignition Problems (Gas TXT Models)

Gas EZGO TXT models face a different set of troubles centered around the fuel system, ignition system, and starter-generator.

Symptoms

• Hard starting

• Surging or hesitation

• Stalling after warm-up

• Battery not charging while running

What to inspect

• Spark plug condition (fouled, wet, or worn)

• Fuel filter and fuel line blockage

• Dirty or gummed-up carburetor

• Weak ignition coil

• Starter/generator belt tension

If fuel system parts need replacement, see our carburetors, ignition coils, and fuel pumps in the EZGO Gas Parts section.

5. Steering, Suspension & Brake Wear

Mechanical components degrade with time, especially on carts used for off-road or neighborhood driving.

Warning signs

• Loose or wandering steering

• Bumpy ride

• Longer braking distance

• Clicking during sharp turns

What to check

• A-arm bushings

• Tie rod ends

• Steering box

• Shock absorbers

• Brake shoes, cables, and the equalizer

For upgrades or replacements, explore our EZGO suspension parts, including shock absorbers, bushings, and brake components — all engineered for durability.

6. Wiring and Ground Issues

A single loose ground can mimic multiple major failures.

Look for

• Flickering lights

• Controller fault codes

• Heat spots along cables

• Wires chewed by rodents

Re-securing grounds and replacing deteriorated wiring often restores function instantly.

When to Replace Parts vs. When to Repair

Repair is usually enough when:

• Terminals only need cleaning

• Micro-switches respond after adjustment

• Fuses were loose or corroded

• Throttle pedal position sensor simply needed realignment

Replace the part when:

• Connectors or terminals are melted

• Motor smells burnt

• Batteries show swelling or cracking

• Ignition coil fails spark testing

• Fuel pump has weak or inconsistent output

10L0L provides OEM-compatible, long-life upgrades for EZGO TXT carts, ensuring your maintenance fixes truly last.

Quick Diagnostic Flowchart

1. Electric Cart Won’t Move: Start by checking total battery pack voltage. If it’s below 70% of rated voltage (e.g., below ~38V for a 48V pack), charge it. If the voltage is good, listen for the solenoid click to direct your troubleshooting.

2. Gas Cart Won’t Start: Follow the “Spark, Fuel, Air” mantra. Check for spark at the plug, listen for the fuel pump clicking, and ensure the air filter isn’t clogged. Often, it’s simply stale fuel from last season.

EZGO TXT FAQ

Q: How can I tell if my electric TXT is a Series or a PDS model?
A: Look at the Forward/Reverse control. A heavy lever by your knee indicates a Series drive system. A rocker switch on the dash, accompanied by a “Run/Tow” switch under the seat, indicates a PDS system. This is crucial for buying the correct parts.

Q: My gas TXT runs but backfires loudly when I let off the gas. Why?
A: This is typically a lean condition caused by a vacuum leak (check intake gaskets and hoses) or a clogged pilot jet in the carburetor from old fuel.

Q: What’s the most important maintenance task for each type?
A: For Electric: Rigorous battery maintenance and terminal cleaning. For Gas: Regular engine oil changes and annual valve lash adjustment. Neglecting these guarantees major problems later.

When to Call a Professional

While many TXT issues are DIY-friendly, some—like internal motor brush replacement, head gasket repairs, or complex controller diagnostics—require specialized tools and expertise. If you’re ever in doubt, consulting a certified technician can prevent a simple fix from becoming a costly repair.

Pro Tip: Always note your cart’s model year and manufacture code (from the tag in the passenger-side glove box or under the seat) when searching for parts or troubleshooting. Need help finding the right part for your specific model? Use our [EZGO Parts Finder & Compatibility Guide] to ensure a perfect match.